Understanding the role of sulfur-thiamine interaction in the pathogenesis of sulfur-induced polioencephalomalacia in beef cattle.

This study examined the role of sulfur (S) in the pathogenesis of S-induced polioencephalomalacia (PEM) in beef cattle in the context of thiamine status and metabolism. Thiamine, thiamine monophosphate (TMP) and thiamine pyrophosphate (TPP) status in rumen fluid, blood and brain tissue were determined in beef heifers fed 2 levels of S [low S (LS) vs. high S (HS)] at 2 forage-to-concentrate ratios (F:C). High S diet did not affect ruminal and blood thiamine status. Interestingly, however, HS diet showed increased brain thiamine levels. No gross or histopathological changes indicative of PEM were detected in the brains of the heifers. Of note, during the course of the present study, we documented an outbreak of S-induced PEM in commercial feedlot steers. Brain thiamine variables in experimental animals fed HS diet were then contrasted with brain thiamine status in PEM affected feedlot steers. Interestingly, in clinically normal animals, exposure to HS diet resulted in increased levels of both TMP and TPP in the brain tissue, in comparison to animals fed LS diet. In contrast, the PEM affected brains showed overall lower levels of thiamine phosphates. It is noteworthy that TPP levels were 36.5% lower, despite 4.9-fold higher free thiamine in PEM brains compared to normal brains. Our results indicate that high dietary S may increase the metabolic demand for TPP, and that animals incapable of maintaining requisite levels of brain TPP are at high risk to develop fulminant cerebrocortical necrosis.

Characteristics of cold-induced dark, firm, dry broiler chicken breast meat.

1. A study was designed to characterise dark, firm, dry (DFD) breast meat resulting from cold exposure of broilers and compare its properties with normal breast meat from cold-stressed and control birds. 2. A total of 140 broilers were selected from 5- and 6-week-old birds exposed to cold temperatures ranging from -18 to -4°C, or a control temperature of +20°C for 3 h in an environmental chamber. Half of these birds were slaughtered immediately following the cold exposure and the other half were given 2 h of lairage. 3. Breast meat samples were categorised based on ultimate pH (pH(u)) and colour L* (lightness) values into normal (5·7 ≤ pH(u)≤ 6·1; 46 ≤ L* ≤ 53) breast meat from control (control-normal) or cold-stressed (cold-normal) birds, and DFD (pH(u) > 6·1; L* < 46) breast meat, which only occurred in cold-stressed birds (cold-DFD). 4. Residual glycogen was not different between cold-DFD and control-normal breast meat. Lactate concentration was lower in cold-DFD compared with control-normal breast meat. Lactate concentration almost tripled for all the samples by 30 h post-mortem, which resulted in a drop in pH of normal meat, but did not have any effect on pH of DFD breast meat. Glycolytic potential at both 5 min and 30 h post-mortem was lower in DFD breast meat compared with the normal breast meat from both cold-stressed and control birds. 5. Cold-DFD breast meat was significantly darker, with higher pH(u), lower cook loss, higher water-binding capacity and processing cook yield than cold-normal and control-normal breast meat, which were not different from each other.

Broiler chicken thigh and breast muscle responses to cold stress during simulated transport before slaughter.

The effect of acute cold exposure was assessed on broiler physiology, breast and thigh muscle metabolites, and meat quality. In total, 160 male birds at ages of 5 and 6 wk were exposed to temperatures of -9 to -15°C (cold stressed) and +20°C (control) in a simulated transport chamber for 3 h before slaughter followed by 0 or 2 h of lairage. Bird physiology parameters, including core body temperature, live shrink, blood glucose, and muscle temperature, were assessed. Core body temperature was monitored every minute using i-Button data loggers, and live shrink and blood glucose were assessed. Total glucose and lactate concentrations at 30 h postmortem, as well as ultimate pH (pH(u)), color, and water-holding attributes were evaluated on pectoralis major muscle of breast and iliotibialis muscle of thigh. Birds were grouped based on their microclimate temperature to control and cold-stressed groups (0 to -8, -8 to -11, and -11 to -14°C). Significant (P < 0.05) decreases in core body temperature and breast and thigh muscle temperatures were observed at simulated transport temperatures below 0°C. In addition, higher (P < 0.05) live shrink and lower blood glucose values were observed as a result of 3-h exposure to temperatures below 0°C, exacerbated as temperature decreased further below -8°C. Thigh muscle was almost depleted of glycogen reserve compared with a significant but small reduction in breast muscle glycogen when exposure temperature was below -8°C. Similarly, much greater effects were observed on thigh pH(u) and quality attributes compared with breast. In addition, 84% incidence of the dark, firm, dry quality defect was observed in thigh meat (pH(u) > 6.4, L* < 44) compared with 42% incidence of dark, firm, dry in breast meat (pH(u) > 6.1, L* < 46) when transportation temperature was below 0°C. Results of this study showed that thigh muscle was affected more severely than breast muscle by exposure to cold temperatures before slaughter.

The effect of simulated cold weather transport on core body temperature and behavior of broilers.

During the winter in Western Canada, broilers are routinely transported in ambient temperatures ranging from 0°C to -40°C, yet there is little research in this area. This study examined the physiology and behavior of broilers undergoing simulated transport at typical Western Canadian winter temperatures. Groups of 15 broilers aged 32 to 33 d were exposed to an air stream regulated to -5, -10, or -15°C. Birds were placed into a typical transport drawer. Following baseline observations, the drawer was placed into a test chamber where cold air was drawn past the birds for 3 h. Three replications were conducted at each temperature. The birds adjusted their position within the drawer based upon the temperature distribution within the drawer. In comparison to the baseline period, exposing the birds to a cold air stream caused them to avoid the front plane (P = 0.003) which was the coldest area within the drawer. The birds did not adjust their usage of the middle (P = 0.308) and rear (P = 0.640) planes, because these were the warmer areas within the drawer. The total amount of space the birds occupied within the drawer did not decrease when exposed to the test chamber (P = 0.669). The core body temperature (CBT) did not vary and was within the known normal range during the normal (P = 0.528), pre-chamber (P = 0.060), and post-chamber (P = 0.285) periods. The CBT of the birds significantly decreased during the in-chamber period (P < 0.001) and then increased during the lairage period (P < 0.001). The shrink loss (P = 0.981) and amount of time to resume feed consumption (P = 0.357) were not affected by exposing the birds to temperatures of -5°C and colder. Exposing birds to temperatures of -5°C and colder had a negative effect on the CBT of the birds. However, the birds demonstrated behaviors which mitigated the negative effect that cold exposure could have on their CBT.

Heat and moisture production by broilers during simulated cold weather transport.

To ensure broiler welfare during winter transport, it is necessary to manage heat and moisture accumulation within the transport vehicles. Hence, it is necessary to determine heat production (HP) and moisture production (MP) rates under representative conditions. An environmental chamber containing a standard transport drawer was used. Cold air was drawn from outside the building, warmed to the desired temperature, and passed through the drawer at 0.35 m(3)/s. Broilers were fasted for 7 h, placed into the drawer, and exposed to test conditions within the chamber for 3 h. Air temperature and RH were measured upstream and downstream of the insulated bird compartment at 1-min intervals. Differences in the paired temperature and RH values were used to calculate sensible HP and MP for each 1 min of confinement. Effects of temperatures between -8 and -18°C and a control (+20°C) were measured for birds in 2 conditions. In condition A, there were 15 birds/drawer. Birds were 32 to 33 d old and weighed 1.8 kg. Packing density was approximately 27 kg/drawer (31 kg/m(2)). In condition B, there were 19 or 22 birds/drawer. The drawers with 19 birds contained birds that were 39 to 40 d old that weighed 2.68 kg. In the drawers with 22 birds, the birds were 35 to 36 d old and weighed 2.29 kg. In either case, the packing density was approximately 50 kg/drawer (59 kg/m(2)). Thus, the birds in condition B were bigger, more numerous, and more tightly packed than the birds in condition A. Drawers were balanced for sex. At +20°C, HP and MP rates were similar to other published values. However, for both conditions, HP and MP rates increased with decreasing exposure temperatures. In condition A, HP was 6.08 ± 0.43 W/kg and MP was 4.46 g/h per kg at 20°C compared with 87.5 ± 10.3 W/kg and 22.08 ± 5.05 g/h per kg at -15°C. In condition B, HP was 8.12 ± 1.24 W/kg and MP was 5.53 ± 1.68 g/h per kg at 20°C compared with 45.92 ± 1.95 W/kg and 12.33 ± 0.22 g/h per kg at -18°C.

Effect of acute cold exposure, age, sex, and lairage on broiler breast meat quality.

The effect of acute cold exposure on bird physiology, muscle metabolites, and meat quality was assessed in 360 male and female broilers at 5 and 6 wk of age, exposed for 3 h to temperature ranges of -18 to -4°C and a control of +20°C, by using a simulated transport system followed by 0 or 2 h of lairage. Core body temperature (CBT) was recorded, and the microclimate temperature and RH surrounding individual birds were monitored. Birds were classified based on the temperature in their immediate surroundings. Exposure to temperatures below 0°C resulted in a decrease (P < 0.05) in blood glucose and an increase in live shrink. During the 3 h of exposure to -8°C or lower, CBT dropped substantially. Temperatures below -14°C caused lower glycolytic potential and lactate concentrations. Five-week-old birds showed darker and redder breast meat with higher ultimate pH (pH(u)), less cook loss, and higher processing cook yield at temperatures below -8°C compared with warmer temperatures and with 6-wk-old birds exposed to similar temperatures. No difference in meat quality was observed between the 2 ages at temperatures below -14°C. Males had a greater decrease in CBT and had breast meat with higher pH(u) compared with females. The 2-h lairage resulted in darker breast meat with higher pH(u) at exposure temperatures below -14°C and with higher water-binding capacity and processing cook yield at temperatures below -11°C. A high (>57%) incidence of dark, firm, and dry breast meat [pH >6.1 and L* (lightness) <46] was observed at temperatures below -14°C. A 2-h lairage resulted in an additional 20% increase in the incidence of dark, firm, and dry meat at temperatures below -8°C. Results of this study showed that older birds coped better with extreme cold conditions compared with younger birds. Furthermore, it would be beneficial to limit the length of lairage before processing after exposure to acute cold to improve bird welfare and reduce meat quality defects.

Effects of moisture enhancement, enzyme treatment, and blade tenderization on the processing characteristics and tenderness of beef semimembranosus steaks.

The individual and combined effects of moisture enhancement with a salt/phosphate solution (ME), blade tenderization (BT), and enzyme injection with proteinases derived from Aspergillus oryzae or Bacillus subtilis on cooking properties, Warner-Bratzler shear force (WBSF), and sensory characteristics of beef semimembranosus were investigated. ME significantly (P < 0.01) reduced WBSF and increased (P < 0.05) sensory scores for juiciness and tenderness. BT increased (P < 0.05) initial and overall tenderness scores and made connective tissue less perceptible. BT combined with ME resulted in the highest initial and overall tenderness scores, however, combining ME with either proteinase was as effective for reducing WBSF and increasing tenderness, particularly at 20 (vs. 10) ppm enzyme inclusion. Tenderness of enzyme-injected steaks was increased without compromising other palatability attributes. All treatments increased the frequency of steaks rated slightly tender or higher, with the ME+BT combination, or ME with inclusion of 20 ppm of either proteinase, being most effective.

Influence of blade tenderization, moisture enhancement and pancreatin enzyme treatment on the processing characteristics and tenderness of beef semitendinosus muscle.

The combined effect of blade tenderization (BT), moisture enhancement and enzymatic tenderization on drip loss, cook loss, Warner-Bratzler shear force (WBSF) and sensory characteristics of beef semitendinosus (ST) steaks from cattle under 30 months of age was investigated. Injection with phosphate/chloride solution improved tenderness and juiciness of ST muscles (P<0.01). No additional improvement in tenderness was observed with incorporation of a pancreatin enzyme preparation into the moisture enhancement solution (P>0.1). Injection of pancreatin alone tended to improve overall tenderness (P=0.09) and did not adversely affect other palatability attributes. Blade tenderization of ST muscles improved tenderness, as indicated by lower WBSF and increased sensory tenderness scores than for control samples, without decreasing flavour and juiciness. The results suggest that moisture enhancement and blade tenderization can be effectively utilized to reduce the variability in and improve both tenderness and palatability of ST muscles. Pancreatin was not particularly effective at the 0.02% level used.

Effect of microclimate temperature during transportation of broiler chickens on quality of the pectoralis major muscle.

This study investigated the effect of microclimate temperature during preslaughter transportation on chicken meat quality. Ninety broilers per load of 2,900 were monitored individually during 3 to 4 h of preslaughter transport in an actively ventilated trailer. Six transport test runs were conducted at average ambient temperatures of -27, -22, -17, -5, +4, and +11 degrees C. Birds were classified into 4 groups based upon the temperatures recorded in their immediate surroundings as follows: -16 to 0, 0 to 10, 10 to 20, and 20 to 30 degrees C. Internal body temperatures of the birds were recorded using Thermocron DS1922L iButtons. Birds were slaughtered in a commercial facility and meat quality of the chilled carcasses was evaluated by determination of pH, color, drip loss, thaw loss, cook loss, shear force, water-binding capacity, and pellet cook yield of the pectoralis major muscle. The breast meat from birds exposed to temperatures below 0 degrees C showed a significantly higher (P < 0.05) ultimate pH. Breast meat from birds exposed to temperatures below 0 degrees C showed significantly higher (P < 0.05) ultimate pH, a* value, water-binding capacity, and pellet cook yield and a significantly lower L* compared with breast meat of birds exposed to temperatures above 0 degrees C. The average core body temperatures were significantly lower (P < 0.05) during transport for birds exposed to temperatures below 0 degrees C compared with those exposed to temperatures between 0 and 10 degrees C. The latter birds had significantly lower (P < 0.05) core body temperatures compared with those exposed to temperatures above 10 degrees C. Thaw loss was significantly higher (P < 0.05) for breast meat of birds exposed to temperatures above 20 degrees C during transportation. There was no significant trend for b* value, drip loss, cook loss, or shear values based on environment temperature immediately surrounding the birds. Exposure to temperatures below 0 degrees C increased the incidence of dark, firm, and dry breast meat and decreased the incidence of pale, soft, and exudative breast meat. These results demonstrate that preslaughter transport may influence breast meat quality characteristics of broiler chicken.

Effect of muscle location, fiber direction, and slice thickness on the processing characteristics and tenderness of beef stir-fry strips from the round and chuck.

The objective was to assess different beef muscles for use as stir-fry. Inside round, outside round, eye of round, knuckle, chuck clod, and chuck tender were obtained from six beef carcasses. Different slice thickness (2, 4, or 8mm) and muscle fiber direction were evaluated. Slices were cooked from frozen on a flat grill and then cut into strips for shear and sensory testing. While meat cut had little effect on shear values of these thin slices, increasing slice thickness greatly affected tenderness and cook yield. The sensory panel found that strips from the knuckle were more tender and juicy, with less connective tissue and with a better flavor than that of slices from the eye of round and outside round. Increasing slice thickness resulted in detection of greater amounts of connective tissue but did not result in a significant difference in the perception of tenderness. Fiber direction was also of importance. Slices removed perpendicular to the fiber direction had shear values up to 50% lower than slices removed parallel.

Effects of mechanical treatments and moisture enhancement on the processing characteristics and tenderness of beef semimembranosus roasts.

The combined effect of blade tenderization (TD,NTD), pre-massaging (0 and 30min), moisture enhancement and post-injection tumbling (2h) on the chemical, binding and textural characteristics of pre-cooked roasts made from beef top round was investigated. Properties of the beef roasts were determined by measuring processing (i.e., cooking yield, expressible moisture (EM)) and textural characteristics (Warner-Bratzler shear, Kramer shear (KS), texture profile analysis). Brine injection helped to improve the cook yield and had the largest effect on tenderness of semimembranosus muscles. Post-injection tumbling did not significantly improve yield and textural properties of roasts; however, combined with the tenderization, it had beneficial effects on water holding and moisture retention. Pre-tumbling and blade tenderization treatments prior to injection generally were found to be beneficial for textural characteristics; pre-tumbling also tended to improve cook yield, but did not influence EM. However, no synergistic effect between these two variables was observed. An interaction between injection/tumbling and pre-tumbling was observed for KS. There was a significant improvement of KS values of roasts due to pre-tumbling observed for either non-injected roasts or those injected but without tumbling. However, no additional reduction in shear force was observed with pre-tumbling when roasts were tumbled after injection. This suggests that pre-tumbling may not be necessary to ensure more tender roasts when post-injection tumbling is applied, but would be beneficial for non-injected roasts or when tumbling is not applied after injection.

Effect of blade tenderization and tumbling time on the processing characteristics and tenderness of injected cooked roast beef.

The combined effect of blade tenderization (T, NT) and tumbling time (0, 2, 16 h) on quality characteristics of cooked beef roasts processed with 20 or 40% injection level was investigated. Properties of the beef roasts were determined by measuring processing and textural characteristics (shear force, texture profile analysis). Extended tumbling (to 16 h) favorably affected hydration properties and thermal stability, yielding lower cooking loss and purge and higher WHC for beef roasts. It also decreased shear force and hardness of beef samples by 50-60%, but was unable to increase cohesiveness. Blade tenderization prior to injection generally was found to be beneficial for textural characteristics, tended to improve cook yield, but did not influence other hydration properties. An interaction between tenderization and tumbling was observed for shear force. Blade tenderization decreased shear values by 15-20% for roasts tumbled for 0 or 2 h, but did not improve tenderness with extended tumbling.

The effect of quantity and timing of brine addition on water binding and textural characteristics of cooked beef rolls.

The combined influence of quantity and timing of water/sodium chloride/phosphate addition on quality characteristics of beef rolls processed with 25 or 50% brine level was investigated. Properties of beef rolls were determined by measuring hydration and textural characteristics. The higher level of brine addition (50%) had detrimental effects on product water binding and textural characteristics. Late addition of brine/water during tumbling (i.e. during the last hour) resulted in rolls which were less hard, chewy and elastic, and had poorer water holding properties. Addition of brine in two parts favourably affected hydration properties and thermal stability, yielding lower cooking loss and purge and higher WHC, irrespective of level of brine addition. It also increased hardness and chewiness and improved springiness, cohesiveness and bind of cooked beef rolls.

Palatability of bison semimembranosus and effects of marination.

The present study was conducted to investigate the palatability of bison semimembranosus muscle (SM) and the effects of injection with sodium chloride and sodium tripolyphosphate on cooking yield, colour, shear force and consumer acceptability. Twenty paired SM were obtained from 10 intact male bison (aged 24-30 months); each of these muscles was divided longitudinally into two sections. One section was injected to 110% of its original weight to contain 0.5% sodium chloride and 0.3% sodium tripolyphosphate, while the other was kept as a non-injected control. HunterLab a* (redness) and b* (yellowness) values did not differ (P>0.05) between injection treatments; however, injected steaks had lower L* values (darker) compared to controls. Control samples from bison SM were very lean and high in protein but not very tender. Marination by injection was able to significantly reduce shear force values of SM; that is, injected steaks/roasts had significantly (P<0.001) lower shear force values (63.9 N) compared to control samples (102.3 N). Cooking yields for the steaks/roasts from the injected sections were significantly (P<0.001) higher compared to those from control non-injected sections when cooked to either 71 or 77 °C. Bison samples cooked by moist-heat had significantly (P<0.001) lower cooking losses and shear force values compared to those cooked by dry-heat. As expected, steaks/roasts were more tender and had higher cooking yields when cooked to a medium level of doneness (71 °C) compared to an internal temperature of 77 °C (well done). A panel of 80 consumers preferred injected steaks cooked to 77 °C endpoint over other combinations, followed by non-injected steaks cooked to 71 °C, whereas injected steaks cooked to 71 °C and non-injected steaks cooked to 77 °C were equally but least preferred. Hence, injection seems to be protecting against moisture loss at high end-point cooking temperatures.

Meat cut and injection level affects the tenderness and cook yield of processed roast beef.

The effect of muscle cut used and brine injection level on the processing characteristics of small pre-cooked roast beef was determined. Meat cuts (inside, outside, eye of round, knuckle, clod, chuck roll and brisket) were cut into small roasts (750 g) and injected at three levels (110, 125 and 150% over raw roast weight) with a non-injected control. Muscle cuts from the chuck can be used to successfully manufacture cooked mini roast beef. However, the use of small roasts resulted in cook yields that are considerably less than what was expected with large intact muscle roasts. Some variation in tenderness between the muscles was seen, but when muscles were injected there was a significant increase in tenderness and a reduction in the variability in tenderness within the muscle. Roasts injected to 125% above green weight resulted in the highest cook yields.

Effect of L-glucose and D-tagatose on bacterial growth in media and a cooked cured ham product.

Cured meats such as ham can undergo premature spoilage on account of the proliferation of lactic acid bacteria. This spoilage is generally evident from a milkiness in the purge of vacuum-packaged sliced ham. Although cured, most hams are at more risk of spoilage than other types of processed meat products because they contain considerably higher concentrations of carbohydrates, approximately 2 to 7%, usually in the form of dextrose and corn syrup solids. Unfortunately, the meat industry is restricted with respect to the choice of preservatives and bactericidal agents. An alternative approach from these chemical compounds would be to use novel carbohydrate sources that are unrecognizable to spoilage bacteria. L-Glucose and D-tagatose are two such potential sugars, and in a series of tests in vitro, the ability of bacteria to utilize each as an energy source was compared to that of D-glucose. Results showed that both L-glucose and D-tagatose are not easily catabolized by a variety of lactic bacteria and not at all by pathogenic bacteria such as Escherichia coli O157:H7, Salmonella Typhimurium, Staphylococcus aureus, Bacillus cereus, and Yersinia enterocolitica. In a separate study, D-glucose, L-glucose, and D-tagatose were added to a chopped and formed ham formulation and the rate of bacterial growth was monitored. Analysis of data by a general linear model revealed that the growth rates of total aerobic and lactic acid bacteria were significantly (P < 0.05) slower for the formulation containing D-tagatose than those containing L- or D-glucose. Levels of Enterobacteriaceae were initially low and these bacteria did not significantly (P < 0.20) change in the presence of any of the sugars used in the meat formulations. Compared to the control sample containing D-glucose, the shelf life of the chopped and formed ham containing D-tagatose at 10 degrees C was extended by 7 to 10 days. These results indicate that D-tagatose could deter the growth of microorganisms and inhibit the rate of spoilage in a meat product containing carbohydrates.

Recovery of proteins from beef bone and the functionality of these proteins in sausage batters.

Four solutions [4% sodium chloride (control), 4% sodium chloride with 0.3% sodium tripolyphosphate (STP), 0.3% tetrasodium pyrophosphate (TTP) or 0.05 M sodium hydroxide (NaOH)] were used to extract proteins from beef bones. Three bone solution ratios (1:1, 1:4 or 1:10), three bone types [vertebra (lumbar), rib (4-7) and leg (femur)] and two methods of protein recovery from the extraction slurries [dialysis against 0.03 M potassium phosphate buffer (pH 5.3) and acid precipitation] were evaluated. Solutions containing phosphates or NaOH were more effective in extracting protein than sodium chloride alone. Total protein recovery was highest from vertebra bones while extraction of proteins from leg bones resulted in the lowest recovery. A solution to bone ratio of 1 to 10 recovered more total protein from vertebra or rib bones than leg bones. Dialysis recovered more total protein from extraction solutions when the protein concentration was low. Acid precipitation, however, worked best if the protein concentration in the extraction solution was high. Extraction procedures resulted in some myosin degradation. Proteins extracted from beef bone materials and recovered by dialysis, performed equally as well as other commercially available proteins when added to a finely comminuted sausage product.

Rapid post-mortem glycolysis and delay chilling of turkey carcasses cause alterations to protein extractability and degradation of breast muscle proteins.

SDS-PAGE banding patterns of myofibrillar protein samples from turkey breast muscle with pH < or =5.8 at 15 min post-mortem (rapid glycolyzing) contained 133, 142, and 165 kDa bands that were absent in samples from carcasses with pH >6.0 at 15 min post-mortem (normal glycolyzing). These extra protein bands contained fragments of myosin as identified by Western blot analysis. Myosin fragments were also observed in protein samples from breast muscle not allowed to cool until 110 min post-mortem (delay chilled). In addition to myosin degradation, neublin degradation was more extensive in samples from rapid glycolyzing carcasses than for normal controls. Creatine kinase and glycogen phosphorylase were present in myofibrillar protein extracts of rapid glycolyzing carcasses in higher quantities than in normal controls. Results of this study provide insight into the molecular basis for previously reported reductions in meat quality of rapid glycolyzing and delay chilled turkey meat.

Rapid postmortem pH decline and delayed chilling reduce quality of turkey breast meat.

Effects of rapid postmortem metabolism and delayed chilling on turkey breast meat quality were assessed using color measurements, protein extractability, and gelation characteristics. Based on 15 min postmortem breast muscle pH, tom turkey carcasses were classified as rapid glycolyzing (RG), pH < 5.80, or normal glycolyzing (NG), pH > 6.00. Two carcasses per group with similar ultimate pH values were selected on four occasions for a total of 16 carcasses. One half of each carcass was immersion-chilled at 20 min postmortem, the other half was maintained at body temperature for 110 min and then chilled. Breast meat from RG carcasses had higher carcass temperature (15 min) and lower protein (sarcoplasmic and myofibrillar) extractability than breast meat from NG carcasses. Delayed chilling increased all breast meat color values (L*, a*, b*), and decreased protein extractability and cook yield compared to breast meat from immediately chilled carcass halves. The true strain of cooked gels was reduced for RG carcasses. Delayed chilling reduced both true strain and stress of meat gels. There were no interactions between the rate of postmortem pH decline and initiation of chilling, indicating that reductions in meat quality due to delayed chilling were independent of the carcass classification for rate of postmortem glycolysis. Results indicate that factors that affect both rate of postmortem glycolysis and carcass temperature decline are important to turkey breast meat quality.

Effects of raw binder system, meat cut and prior freezing on restructured beef.

The effect of different meat cuts or previously frozen meat on processing properties of restructured beef bound with alginate or Fibrimex(TM) was investigated. Inside rounds, chuck tenders, chuck clods and tri-tip were used to manufacture restructured logs. Steakettes manufactured with alginate had significantly (P<0.05) higher particle bind in the raw state but Fibrimex had greater bind between meat pieces after cooking. Choice of cut or use of previously frozen meat to manufacture restructured steakettes had no effect on any of the processing parameters measured. Steakettes made with Fibrimex were lighter, redder and yellower than those made with alginate. Redness and yellowness of steakettes decreased with retail storage time. However, the change in redness and yellowness over time was similar for both binders. Use of previously frozen meat resulted in a darker, less red steakette. When alginate was used to manufacture steakettes, cut had no affect on the acceptability of steakettes. However, when Fibrimex was used steakettes made from clod and tip were preferred by a consumer panel to steakettes made from tender and inside round.